2001 Fleetwood Bounder recalls and problems
The 2001 Fleetwood Bounder has 5 safety recalls and 8 owner complaints filed with NHTSA. Recall repairs are free at any Fleetwood dealer.
Recalls may cover only some 2001 Fleetwood Bounder vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2001 Fleetwood Bounder recalls
Recall 09V-198: Service Brakes, Air
Problem: Fleetwood is recalling 509 my 2001-2008 class a motor homes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver.
Risk: The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
Fix: Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy for this campaign please see 09v-110. The manufacturer has not yet provided an owner notification schedule. Owners may contact workhorse at 1-877-246-7731. Workhorse will conduct the owner and dealer notification.
Recall 08V-240: Equipment
Problem: Fleetwood is recalling certain class a gas and diesel motor homes, class c motor homes, conventional and fifth wheel travel trailers equipped with norcold refrigerators. A low cycle fatigue failure in the section of the cooling unit which generates the refrigerant could allow the liquid solution to slowly leak.
Risk: Extended operation of a leaking cooling unit could lead to a fire from gas which might escape.
Fix: Fleetwood is working with norcold to repair these refrigerators. Norcold will provide thermal switch kits to owners along with the necessary forms and instructions. The recall is expected to begin during june 2008. Owners may contact norcold at 1-800-767-9101 or fleetwood at 1-800-509-3418.
Recall 07V-120: Equipment
Problem: Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (Gas flame) is present.
Risk: Release of coolant under certain conditions could ignite and result in a fire.
Fix: Fleetwood will be working with dometic in order to repair these refrigerators (Please see 06e076). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216.
Recall 03V-452: Equipment
Problem: On certain travel trailers equipped with samsung microwave ovens, these ovens were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
Risk: An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
Fix: Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or fleetwood at 1-800-629-8454.
Recall 03V-066: Service Brakes, Hydraulic
Problem: Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "hydraulic and electric brake systems." the brake system warning indicator may not function as required by standard.
Risk: In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator.
Fix: Dealers will repair these vehicles. Owner notification began april 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact fleetwood at 1-800-445-3307.
2001 Fleetwood Bounder problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Engine and Engine Cooling | 4 | |
| Equipment | 3 | |
| Structure | 3 | |
| Electrical System | 2 | |
| Unknown or Other | 2 | |
| Vehicle Speed Control | 2 | |
| Steering | 1 | |
| Wheels | 1 | |
| Service Brakes, Air | 1 | |
| Fuel System, Gasoline | 1 |
Most reported parts
- Engine and Engine Cooling › Engine › Gasoline — 3
- Steering › Linkages › Knuckle › Spindle › Arm — 1
- Electrical System › Wiring — 1
- Engine and Engine Cooling › Engine — 1
- Structure › Body — 1
- Equipment › Electrical › Radio/Tape Deck/Cd Etc. — 1
- Fuel System, Gasoline › Storage › Tank Assembly — 1
Typical mileage at the time of the problem: 12,127 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2001 Fleetwood Bounder complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Fleetwood Bounder years
Frequently asked questions
Does the 2001 Fleetwood Bounder have any recalls?
Yes — NHTSA lists 5 recalls for the 2001 Fleetwood Bounder: 09V-198 (service brakes, air), 08V-240 (equipment), 07V-120 (equipment), 03V-452 (equipment), 03V-066 (service brakes, hydraulic). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2001 Fleetwood Bounder?
Owners report engine and engine cooling problems most often (4 reports), followed by equipment (3). The typical mileage when problems were reported is about 12,127 miles.
Are Fleetwood recall repairs free?
Yes. Safety recall repairs are free at authorized Fleetwood dealers, whether you are the first owner or bought the car used.