2006 Damon Challenger recalls and problems
The 2006 Damon Challenger has 6 safety recalls and 3 owner complaints filed with NHTSA. Recall repairs are free at any Damon dealer.
Recalls may cover only some 2006 Damon Challenger vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2006 Damon Challenger recalls
Recall 09V-225: Service Brakes, Hydraulic
Problem: Damon is recalling 2,415 motorhomes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag.
Risk: The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
Fix: Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign please see 09v-110. Owners may contact workhorse at 1-877-246-7731.
Recall 08V-534: Equipment
Problem: Damon is recalling 4,677 my 2004-2006 challenger, daybreak, intruder, my 2004-2005 escaper, ultrasport, and my 2005 astoria and astoria waldorf motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (Gas flame) is present.
Risk: Release of coolant under certain conditions could ignite and result in a fire.
Fix: Damon will be working with dometic in order to repair these refrigerators (Please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or damon at
Recall 07V-022: Exterior Lighting
Problem: Certain motor homes fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps reflective devices, and associated equipment." these motor homes were built without the red rear reflex reflectors and some motor homes were built without the side rear red reflex reflectors.
Risk: During night driving conditions or while the motor home is parked, the rear and side marker lights will not provide any reflex reflection to mark the vehicle's location in the dark increasing the risk of a crash.
Fix: Damon will provide the owners with a kit containing the missing reflectors and instructions for applying them to their vehicle. Owners may choose to have their dealers do the repair free of charge. The recall began on july 9, 2007. Owners may contact damon at 1-800-860-3812.
Recall 06V-451: Engine and Engine Cooling
Problem: On certain motor homes built on workhorse chassis and equipped with GM 8.1l v8 engines, improper hardening during the heat treatment process can cause the fuel rail pulse damper retainer clip to fracture, resulting in inadequate retention of the damper. If the damper becomes loose, fuel could be pumped by the fuel pump into the under hood area.
Risk: In the presence of an ignition source, a fire could result.
Fix: Chevrolet and workhorse are handling the owner notification and remedy for this campaign (Please see 06v225 and 06v289). Dealers will replace the fuel rail pulse damper retainer clips on these engines free of charge. Owners may contact chevrolet at 1-800-630-2438, workhorse at 877-294-6773, or damon at 1-574-264-5517.
Recall 06V-347: Equipment
Problem: On certain class a motor homes, some hydraulic lines for the leveling jack system may be improperly secured or routed too close to a drive train heat source.
Risk: This may cause melting of the hydraulic line resulting in leakage of hydraulic fluid, which could cause a fire.
Fix: Damon will inspect and secure the clearance of the hydraulic leveling hose that may be too close to heat sources. The recall began on september 25, 2006. Owners may contact damon at 1-800-860-3812.
Recall 06V-236: Steering
Problem: Certain motor homes built on workhorse chassis may have been equipped with incorrect steering intermediate shafts. The spline can strip while the steering wheel is being turned.
Risk: This steering condition could result in a loss of steering control, increasing the risk of a crash.
Fix: Workhorse is conducting this recall (Please see 06v148000) and will inspect and, if necessary, replace the steering intermediate shaft. Owners may contact workhorse at 1-877-294-6773 or damon at 574-264-2900.
2006 Damon Challenger problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Equipment | 2 | |
| Structure | 1 | |
| Tires | 1 |
Most reported parts
- Structure › Frame and Members — 1
- Equipment › Mechanical › Integrated Jack/Leveler/Stabilizer — 1
Typical mileage at the time of the problem: 6,202 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2006 Damon Challenger complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Damon Challenger years
Frequently asked questions
Does the 2006 Damon Challenger have any recalls?
Yes — NHTSA lists 6 recalls for the 2006 Damon Challenger: 09V-225 (service brakes, hydraulic), 08V-534 (equipment), 07V-022 (exterior lighting), 06V-451 (engine and engine cooling), 06V-347 (equipment) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2006 Damon Challenger?
Owners report equipment problems most often (2 reports), followed by structure (1). The typical mileage when problems were reported is about 6,202 miles.
Are Damon recall repairs free?
Yes. Safety recall repairs are free at authorized Damon dealers, whether you are the first owner or bought the car used.