2003 Crane LCF recalls and problems
The 2003 Crane LCF has 3 safety recalls. Recall repairs are free at any Crane dealer.
Recalls may cover only some 2003 Crane LCF vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2003 Crane LCF recalls
Recall 04V-339: Fuel System, Other
Problem: Certain trucks equipped with nexgen liquid natural gas (Lng) tanks are being recalled. The introduction of water into the discharge side of both the primary and secondary relief valves simultaneously and subsequent freezing in service can render the valves temporarily inoperative.
Risk: If not inspected the risk of tank over-pressurization and a catastrophic tank rupture can occur, potentially resulting in serious injury or death.
Fix: Crane will perform an inspection and provide instructions for ordering and installing the retrofit kit. The recall is expected to begin during july 2004. Owners should contact crane at 918-832-7305.
Recall 03V-241: Engine and Engine Cooling
Problem: On certain heavy duty trucks equipped with cummins westport b gas plus or c gas plus 6 cylinder engines, the electronic control module calibration may not correctly detect a throttle plate actuator failure that could result in an uncommanded open throttle condition.
Risk: If this event occurs, the vehicle operator will not have control of the engine speed which could possibly result in a vehicle crash.
Fix: Both units have already had the electronic control module calibration replaced.
Recall 03V-167: Service Brakes, Air
Problem: On certain trailers equipped with a specific combination of reyco suspension, eaton drive axle, and bendix slack adjusters, the failure of a drive axle slack adjuster to automatically adjust as required to compensate for brake wear, will cause an out of adjustment condition. If this condition occurs and is not identified and corrected through normal inspections and maintenance, the slack adjuster will over-rotate and may contact the suspension lower spring saddle.
Risk: If this occurs, braking performance will be inhibited, increasing the risk of a crash without warning.
Fix: Crane carrier will supply, at no charge, gunite slack adjusters and installation instructions to replace the existing bendix slack adjusters on the drive axle. The installing facility will be reimbursed by crane for one (1) hour labor per vehicle at their posted labor rate. Owner notification began on june 10, 2003. Owners should contact crane at 1-918-832-7305.
Other Crane LCF years
Frequently asked questions
Does the 2003 Crane LCF have any recalls?
Yes — NHTSA lists 3 recalls for the 2003 Crane LCF: 04V-339 (fuel system, other), 03V-241 (engine and engine cooling), 03V-167 (service brakes, air). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are Crane recall repairs free?
Yes. Safety recall repairs are free at authorized Crane dealers, whether you are the first owner or bought the car used.