2004 Country Coach Inspire recalls and problems
The 2004 Country Coach Inspire has 5 safety recalls and 4 owner complaints filed with NHTSA. Recall repairs are free at any Country Coach dealer.
Recalls may cover only some 2004 Country Coach Inspire vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2004 Country Coach Inspire recalls
Recall 07V-241: Exterior Lighting
Problem: Certain motor homes fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the side marker lights in the combination headlight and tail light assemblies do not meet the minimum photometric value and 45 degrees as specified in the standard.
Risk: The inadequacy of the front and rear side marker lights could affect visibility of the motor home during hours of darkness that could potentially result in a motor vehicle crash.
Fix: Dealers will replace the marker lights on the side as close as reasonable to the front and rear corners and wired into the park light system free of charge. The recall began on march 19, 2008. Owners may contact country coach at 1-800-547-8015.
Recall 04V-464: Electrical System
Problem: On certain motor homes, a circuit breaker in the clearance light circuit does not protect the circuit from a too high amperage draw caused by a towed passenger vehicle.
Risk: The circuit breaker can overheat the wire and insulation to a point which could cause a fire.
Fix: Dealers will replace the defective circuit breakers. The recall began on november 8, 2004. Customers can contact country coach at 1-541-998-3720.
Recall 04V-463: Equipment
Problem: On certain motor homes, liquid propane (Lp) gas cook tops were installed using a flexible rubber hose that could burn or melt.
Risk: If undetected, the hose could burn through and result in a LP gas fire.
Fix: Dealers will replace the cook top rubber hose with copper tubing. The recall began on november 8, 2004. Customers can contact country coach at 1-541-998-3720.
Recall 04V-259: Steering
Problem: On certain motor homes equipped with an independent front suspension (Ifs) gen II built by holland USA, the gear plate support gussets were removed. This can allow the plate to flex during a static steer condition.
Risk: The flexing may result in stress cracking which could potentially cause a loss of vehicle steering control which could result in a vehicle crash.
Fix: Holland USA is conducting the owner notification and remedy for this campaign. A bolt-on strengthening of the steering gear plate with u-bolts connecting the cross member to each side of the gear plate at the rear plus a tube support in the front with j-bolts to the gear plate will be installed. Owners should contact holland USA customer service at 1-888-396-6501 for information and instructions for where customers can take their vehicles to have the repairs done free of charge.
Recall 04V-198: Equipment
Problem: Certain motor homes fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." the front tires cold inflation pressures are incorrect. The correct cold tire pressure should be 120 PSI that will support 13,220 pounds.
Risk: This could cause premature tire tread wear or tire failure during normal driving. The premature tire tread wear or tire failure could lead to a loss of steering control, increasing the risk of a crash.
Fix: Dealers will remove and replace new tire labels. Owner notification began april 30, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact country coach at 1-800-547-8015.
2004 Country Coach Inspire problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Visibility | 2 | |
| Exterior Lighting | 1 | |
| Tires | 1 | |
| Equipment | 1 | |
| Electrical System | 1 |
Typical mileage at the time of the problem: 33,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2004 Country Coach Inspire complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Country Coach Inspire years
Compare all Country Coach Inspire years · All Country Coach models
Frequently asked questions
Does the 2004 Country Coach Inspire have any recalls?
Yes — NHTSA lists 5 recalls for the 2004 Country Coach Inspire: 07V-241 (exterior lighting), 04V-464 (electrical system), 04V-463 (equipment), 04V-259 (steering), 04V-198 (equipment). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2004 Country Coach Inspire?
Owners report visibility problems most often (2 reports), followed by exterior lighting (1). The typical mileage when problems were reported is about 33,000 miles.
Are Country Coach recall repairs free?
Yes. Safety recall repairs are free at authorized Country Coach dealers, whether you are the first owner or bought the car used.