2006 Chrysler PT Cruiser recalls and problems

The 2006 Chrysler PT Cruiser has 1 safety recall and 349 owner complaints filed with NHTSA. Recall repairs are free at any Chrysler dealer.

Recalls

Complaints

349

Crashes / fires

35 / 5

Injuries / deaths

25 / 1

Recalls may cover only some 2006 Chrysler PT Cruiser vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2006 Chrysler PT Cruiser recalls

Recall 07V-149: Visibility

Reported Apr 4, 2007 · 38,447 vehicles affected · DAIMLERCHRYSLER CORPORATION

Problem: On certain passenger vehicles, the rear quarter glass attaching fasteners may pull through their mounts and allow the glass to separate from the vehicle.

Risk: If the glass separates while driving, it could strike another vehicle or injure a pedestrian.

Fix: Dealers will replace the rear quarter glass. The recall began on april 30, 2007. Owners may contact daimlerchrysler at 1-800-853-1403.

2006 Chrysler PT Cruiser problems reported by owners

Problem area	Reports
Electrical System	144
Engine	55
Visibility	39
Engine and Engine Cooling	37
Air Bags	35
Power Train	28
Exterior Lighting	21
Steering	18
Structure	15
Electronic Stability Control (ESC)	15
Unknown or Other	13
Visibility/Wiper	11

Most reported parts

Visibility › Glass, Side/Rear — 14
Electrical System › Horn — 13
Engine and Engine Cooling › Engine — 10
Structure › Body — 8
Air Bags › Frontal — 5
Visibility › Windshield — 4
Electrical System › Instrument Cluster/Panel — 4
Equipment › Appliance › Air Conditioner — 3

Typical mileage at the time of the problem: 55,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2006 Chrysler PT Cruiser complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Structure · reported Jun 3, 2022

I heard a strange noise, so I looked under the front end of the car. Saw all that missing. This has happened in the last two weeks. I do not drive in bad weather.

Electrical System · reported Aug 1, 2021

all of the dash board instrument cluster lights turn on breifly,car speed starts to drop, lights on dash turn back off,[ all except seat belt lights] then car seems to restart itself and will reaccelerate.all this happens while we are driving in traffic at highway speeds, this is not good and could result in a very serious incident, not only for us but for othe

Fuel/Propulsion System · at 77,000 miles · reported Jan 5, 2021

Fuel odor in passenger compartment investigated and fuel leak in the engine compartment was found. The leak is at the connection from the fuel tank to the fuel rail connection. The connection is on the vehicle right/passenger side and against the fire wall. If no recall, at least all registered drivers should be notified of the issue. Leak was discovered on 1st look due to google search of issue. Issue is noticed at start up and disappears (Leak continues) with vehicle speed or with air flow dilution. Customers need to fix or face the possibility of a under hood fire. Thanks.

Power Train · at 50,000 miles · reported Oct 16, 2020

The contact owns a 2006 chrysler pt cruiser. The contact stated while driving 45 MPH, the vehicle downshifted to second gear independently. The contact stated no warning light was illuminated. The contact stated he parked on the side of the road. The contact restarted the vehicle and drove to his destination. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the transmission sensor needed to be replaced. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer had not been informed of failure. The failure mileage was…

Power Train · at 100,000 miles · reported Jun 8, 2020

The car has been overheating at idle. When driving, it maintains the correct temperature and returns to it even if it has gone up. Idling at a drive thru is enough to cause a full overheat with smoke. When the car is turned off, a loud bubbling can be heard. The entire fan assembly and harness was just replaced. Problem has been ongoing. Originally, fan would not turn off about 2 years ago. Even when car was off. Spent many months having to remove the fuse because the ran would run the engine dry of power. This would happen even after short drives when the car was in park and off.

Other Chrysler PT Cruiser years

2010 2009 2008 200720062005 2004 2003 2002 2001

Compare all Chrysler PT Cruiser years · All Chrysler models

Frequently asked questions

Does the 2006 Chrysler PT Cruiser have any recalls?

Yes — NHTSA lists 1 recall for the 2006 Chrysler PT Cruiser: 07V-149 (visibility). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2006 Chrysler PT Cruiser?

Owners report electrical system problems most often (144 reports), followed by engine (55). The typical mileage when problems were reported is about 55,000 miles.

Are Chrysler recall repairs free?

Yes. Safety recall repairs are free at authorized Chrysler dealers, whether you are the first owner or bought the car used.