2002 Chevrolet Yukon recalls and problems

There are no safety recalls for the 2002 Chevrolet Yukon, but owners have filed 6 complaints with NHTSA.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2002 Chevrolet Yukon vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2002 Chevrolet Yukon problems reported by owners

Problem area	Reports
Engine and Engine Cooling	3
Service Brakes, Hydraulic	3
Electrical System	1
Parking Brake	1
Fuel System, Gasoline	1
Structure	1
Steering	1
Unknown or Other	1

Most reported parts

Engine and Engine Cooling › Engine — 2
Engine and Engine Cooling › Engine › Gasoline — 1
Electrical System › 12v/24v/48v Battery — 1
Fuel System, Gasoline › Fuel Injection System — 1
Structure › Body › Door — 1
Service Brakes, Hydraulic › Foundation Components › Hoses, Lines/Piping, and Fittings — 1

Typical mileage at the time of the problem: 129,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2002 Chevrolet Yukon complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Unknown or Other · at 203,750 miles · reported May 28, 2018

My wife was driving down the interstate and the line rubbed through and leaked out. She was going 70 m.p.h. The brake lines on drivers side at rear wheel were rubbing and rubbed through. This could have killed her. It is a faulty design, and has nothing to do with rust.

Service Brakes, Hydraulic · at 129,000 miles · reported Jul 29, 2011

The contact owns a 2002 chevrolet yukon xl. The contact stated that when depressing the brakes they extended to the floor and all of the fluid leaked out. The vehicle was taken to a dealer who advised him that all of the brake lines were completely rusted through and needed to be replaced. The brake lines were repaired. The failure and current mileage was approximately 129,000. Updated 08/31/11 the brake lines were replaced twice. Updated 09/09/11.

Engine and Engine Cooling · at 30,000 miles · reported Dec 29, 2004

While driving 45 MPH, the vehicle stalled. The consumer managed to pull over and had the vehicle towed. The cause was not determined. Please provide more information.

Fuel System, Gasoline · at 800 miles · reported Jun 27, 2003

The fuel injection system did not work correctly. The vehicle had been to the dealer on five occasions and the problem still existed. There was a noise coming from under the hood, the pin in the roof continued to fall out, the door did shut properly, the brakes made a noise, the vehicle had a bad steering shaft. Ph

Engine and Engine Cooling · reported May 14, 2002

While driving 5-50 MPH and without warning vehicle will shutdown. After vehicle turns off the battery light will illuminate. Dealer has serviced vehicle 5 times, and has not found the cause.

Other Chevrolet Yukon years

200320022001 2000

Compare all Chevrolet Yukon years · All Chevrolet models

Frequently asked questions

Does the 2002 Chevrolet Yukon have any recalls?

No. NHTSA has no safety recalls for the 2002 Chevrolet Yukon as of this update. Check your VIN at nhtsa.gov/recalls for the latest status.

What is the most common problem with the 2002 Chevrolet Yukon?

Owners report engine and engine cooling problems most often (3 reports), followed by service brakes, hydraulic (3). The typical mileage when problems were reported is about 129,000 miles.

Are Chevrolet recall repairs free?

Yes. Safety recall repairs are free at authorized Chevrolet dealers, whether you are the first owner or bought the car used.