2005 Chevrolet Uplander recalls and problems
The 2005 Chevrolet Uplander has 3 safety recalls and 196 owner complaints filed with NHTSA. Recall repairs are free at any Chevrolet dealer.
Recalls may cover only some 2005 Chevrolet Uplander vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2005 Chevrolet Uplander recalls
Recall 10V-110: Suspension
Problem: The braun corporation has notified NHTSA about a defect in certain model year 2005-2008 general motors mobility conversion, handicapped accessible low floor minivans. During conversion, the driver or passenger side trailing arm modification may not have been adequately welded.
Risk: A squeaking or clunking noise may develop. The trailing arm bushings may prematurely wear and the trailing arm may fracture or separate, allowing the rear axle to become partially separated from the chassis increasing the risk of a crash.
Fix: Dealers will inspect and will have a supply of retrofit parts available to remedy the vehicles free of charge. The safety recall began on june 4, 2010. Owners may contact braun at 1-800-488-0359.
Recall 05V-287: Parking Brake
Problem: Certain sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 135, 'passenger car brake systems.' to meet the standard, the vehicle must not move for five minutes when stopped on a steep hill with the parking brake applied and the vehicle in neutral (N). Some of these vehicles failed this test.
Risk: When the parking brake is released, the driver may notice unintended braking when accelerating, decelerating, or coasting, and a noise coming from the rear of the vehicle. Unintended vehicle movement could occur increasing the risk of a crash.
Fix: Dealers will inspect for parking brake lever slippage at each rear brake caliper and replace the caliper if lever slippage is identified. The recall began on november 14, 2005. Owners may contact buick at 1-866-608-8080, chevrolet at 1-800-630-2438, pontiac at 1-800-620-7668, or saturn at 1-800-972-8876.
Recall 05V-061: Seats
Problem: On certain minivans, the outboard release handle on the impact-side second-row bucket seat may be actuated and the rear latches may unlatch early in a side impact crash. This was discovered in a side impact test run by GM, under conditions similar to NHTSA's new car assessment program (Ncap) side impact test.
Risk: If the rear latches of the seat release early in a severe side impact, the front outboard latch may disengage and increase the potential for injury to the occupant of the seat.
Fix: Dealers will remove the seat latch release handle and install a black plastic cap over the exposed metal stud to eliminate the side impact safety concern free of charge. The recall began on april 5, 2005. Owners may contact saturn at 1-800-972-8876, chevrolet at 1-800-630-2438, and pontiac at 1-800-620-7668.
2005 Chevrolet Uplander problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Electrical System | 63 | |
| Structure | 47 | |
| Latches/Locks/Linkages | 45 | |
| Exterior Lighting | 14 | |
| Service Brakes, Hydraulic | 13 | |
| Suspension | 13 | |
| Steering | 9 | |
| Power Train | 9 | |
| Fuel System, Gasoline | 8 | |
| Engine and Engine Cooling | 8 | |
| Seat Belts | 8 | |
| Seats | 6 |
Most reported parts
- Structure › Body › Door — 28
- Latches/Locks/Linkages › Doors › Latch — 27
- Structure › Body — 11
- Exterior Lighting › Headlights — 6
- Seats › Mid/Rear Assembly — 4
- Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 4
- Electrical System › Alternator/Generator/Regulator — 4
- Electrical System › Starter Assembly — 4
Typical mileage at the time of the problem: 40,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Chevrolet Uplander complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Chevrolet Uplander years
Frequently asked questions
Does the 2005 Chevrolet Uplander have any recalls?
Yes — NHTSA lists 3 recalls for the 2005 Chevrolet Uplander: 10V-110 (suspension), 05V-287 (parking brake), 05V-061 (seats). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2005 Chevrolet Uplander?
Owners report electrical system problems most often (63 reports), followed by structure (47). The typical mileage when problems were reported is about 40,000 miles.
Are Chevrolet recall repairs free?
Yes. Safety recall repairs are free at authorized Chevrolet dealers, whether you are the first owner or bought the car used.