2002 Chevrolet Trailblazer recalls and problems
The 2002 Chevrolet Trailblazer has 12 safety recalls and 1,149 owner complaints filed with NHTSA. Recall repairs are free at any Chevrolet dealer.
Recalls may cover only some 2002 Chevrolet Trailblazer vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2002 Chevrolet Trailblazer recalls
Recall 04V-527: Exterior Lighting
Problem: On certain sport utility vehicles, vibration and heat may cause the tail lamp/stop lamp bulb to loosen in its socket. If this occurs, the bulb may flicker and eventually become inoperative.
Risk: An inoperative brake lamp will not convey the driver's intention of stopping to drivers in following vehicles, and an inoperative rear turn signal lamp will not convey the driver's intention to turn to drivers in following vehicles. Both of these failures can increase the risk of a crash.
Fix: Dealers will inspect the tail lamp/stop lamp assemblies, and if necessary, replace them. The recall began on november 22, 2004. Owners should contact chevrolet at 1-800-630-2438, oldsmobile at 1-800-630-6537, buick at 1-866-608-8080, or gmc at 1-866-996-9463.
Recall 04V-201: Seat Belts
Problem: Certain light duty pickup trucks and sport utility vehicles fail to conform to federal motor vehicle safety standard no. 209, "seat belt assemblies." one of the two sensors in the driver's and front passenger's seat belt retractors could be inoperative. The seat belt retractors will lock when the belt webbing is extracted during a crash; however, the mechanism that locks the seat belt retractor when the vehicle decelerates quickly, such as heavy braking, may not operate as intended.
Risk: If this were to occur, the safety belt may not restrain the occupant as intended during a crash, and could result in injury to the occupant.
Fix: Dealers will inspect the driver and front passenger safety belt retractors, and replace them if necessary. Owner notification began on june 24, 2004. Owners should contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or oldsmobile at 1-800-630-6537.
Recall 04V-046: Visibility
Problem: Certain sport utility vehicles have windshield wiper systems that will not turn on, cease operation while in use, fail to turn off/on by themselves (Moisture sensitive wiper system), or have continuous windshield washer pump operation because the presence of water within the wiper modules can either cause a short circuit or can lead to the corrosion of components within the module.
Risk: Depending on the occurrence and weather situation, driver visibility could be reduced, which could result in a crash.
Fix: Dealers will cover the windshield wiper module vent hole with a patch. Also, the wiper motor, circuit board, and electrical connector will be inspected to signs of water intrusion and/or corrosion and be replaced as required. The recall began july 6, 2004. Owners should contact chevrolet at 1-800-630-2438; oldsmobile at 1-800-630-6537; or gmc at 1-866-996-9463.
Recall 03V-250: Equipment
Problem: Certain minivans, passenger and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." the owner's manual does not explain the meaning of the location symbols for the child restraint lower universal anchorage system.
Risk: This does not meet the requirements of the standard.
Fix: Owners will be provided with a supplement for their owner's manual. This supplement describes and shows the location symbols for the child restraint anchors that are located in the vehicle and on the child restraint or booster cushion. Owner notification began august 18, 2003. Owners should contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, pontiac at 1-800-620-7668, or oldsmobile at 1-800-630-6537.
Recall 03V-096: Electrical System
Problem: Certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standards no. 101, "control location, identification, and illumination" and no. 208, "occupant crash protection." these vehicles have an intermittent condition during vehicle start-up in which the instrument panel cluster may not properly power up, resulting in most of the displays, telltale lights, and functions (Except the service engine light, turn signal indicators, and the instrument panel cluster backlighting) being inoperative.
Risk: These vehicles do not comply with the standard.
Fix: Dealers will reprogram the instrument panel cluster. Owner notification began may 29, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, gmc at 1-800-462-8782, or oldsmobile at 1-800-442-6537.
Recall 03V-075: Power Train
Problem: Certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 114, "theft protection." these vehicles are equipped with a mechanical override that could allow the ignition key to be removed with the shift lever in a position other than park. In addition, these vehicles have an override that can allow the transmission to be shifted out of park with the ignition in the off position.
Risk: These overrides are not permitted unless the vehicle has a locking steering column.
Fix: Dealers will eliminate these conditions by disabling the overrides. Owner notification began on may 29, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, gmc at 1-800-462-8782, oldsmobile at 1-800-442-6537, or hummer at 1-866-486-6376.
Recall 02V-273: Structure
Problem: Certain sport utility vehicles are missing welds on the rear floor plan.
Risk: In a crash, missing welds could degrade performance of the third row seat and safety belt anchorage and occupants could receive greater injuries.
Fix: Dealers will inspect the vehicle for missing welds. If missing welds are found, GM will exchange the vehicle for an equivalent vehicle or provide a refund of the purchase price. Owner notification began october 4, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Recall 02V-121: Fuel System, Gasoline
Problem: On certain sport utility vehicles, a fuel filter fitting can become disconnected. If this were to occur while attempting to start the engine, a no-start condition would result and fuel would be pumped out the fuel filter onto the ground.
Risk: If the fitting becomes disconnected while the vehicle is in motion, the engine would stop due to inadequate fuel supply and cause a loss of power steering assist. If an ignition source were present, fuel leakage from a disconnected fuel filter fitting could result in a fire.
Fix: Dealers will replace the fuel filter quick connect retainers. Owner notification began september 20, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020. Gmc at 1-800-462-8782, or oldsmobile at 1-800-442-6537.
Recall 02V-222: Air Bags
Problem: Certain passenger, mini vans, and sport utility vehicles have an air bag inflator on the driver's side that could fracture at a weld during a deployment.
Risk: Pieces of the inflator could strike and injure vehicle occupants and the air bag cushion would not inflate fully, reducing the capability of the bag to protect the driver.
Fix: Dealers will inspect, and replace, if necessary, the air bag module assembly on the driver's side. Owner notification began august 15, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1-800-521-7300, cadillac at 1-800-458-8006, chevrolet at 1-800-222-1020, gmc at 1-800-462-8782, oldsmobile at 1-800-442-6537, or pontiac at 1-800-762-2737.
Recall 01V-334: Power Train
Problem: Vehicle description: sport utility vehicles equipped with 4-wheel drive. The calibration of the transfer case control module could cause insufficient high speed gear engagement.
Risk: If the gear is not engaged, the vehicle can roll when the transmission is in "park" and a crash could result without warning.
Fix: Dealers will update the transfer case control module calibration to increase gear engagement. Owner notification began november 6, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Recall 01V-283: Power Train
Problem: Vehicle description: sport utility vehicles (4 wheel-drive). Some of these vehicles were built with a range shift collar in the transmission transfer case that contains cracks.
Risk: This condition could result in a complete fracture of the range shift collar and subsequent loss of vehicle forward and reverse gears, and the inability to maintain "park" position. This increases the risk of a vehicle crash resulting from unintended movement of a parked vehicle.
Fix: Dealers will replace the transfer cases and update the control module calibration. Owner notification began september 6, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Recall 01V-126: Suspension
Problem: Vehicle description: sport utility vehicles. Under certain circumstances the front lower control arm brackets may fracture. This fracture could result in separation of the front lower control arm from the frame.
Risk: A separation could result in loss of vehicle control, resulting in a crash.
Fix: Dealers will replace the left and right front lower control arm brackets. Owner notification began by telephone on april 4, 2001. The followup letter to consumers was mailed may 3, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, oldsmobile at 1-800-442-6537, or gmc at 1-800-462-8782.
2002 Chevrolet Trailblazer problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Power Train | 322 | |
| Electrical System | 198 | |
| Exterior Lighting | 154 | |
| Engine and Engine Cooling | 145 | |
| Air Bags | 106 | |
| Fuel System, Gasoline | 106 | |
| Visibility | 105 | |
| Seat Belts | 49 | |
| Steering | 47 | |
| Service Brakes, Hydraulic | 47 | |
| Structure | 42 | |
| Equipment | 35 |
Most reported parts
- Power Train › Automatic Transmission — 163
- Power Train › Transfer Case (4-Wheel Drive) — 68
- Exterior Lighting › Brake Lights — 65
- Engine and Engine Cooling › Engine — 44
- Engine and Engine Cooling › Cooling System › Fan — 33
- Air Bags › Frontal — 25
- Visibility › Windshield Wiper/Washer — 23
- Exterior Lighting › Headlights — 22
Typical mileage at the time of the problem: 65,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2002 Chevrolet Trailblazer complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Chevrolet Trailblazer years
Compare all Chevrolet Trailblazer years · All Chevrolet models
Frequently asked questions
Does the 2002 Chevrolet Trailblazer have any recalls?
Yes — NHTSA lists 12 recalls for the 2002 Chevrolet Trailblazer: 04V-527 (exterior lighting), 04V-201 (seat belts), 04V-046 (visibility), 03V-250 (equipment), 03V-096 (electrical system) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2002 Chevrolet Trailblazer?
Owners report power train problems most often (322 reports), followed by electrical system (198). The typical mileage when problems were reported is about 65,000 miles.
Are Chevrolet recall repairs free?
Yes. Safety recall repairs are free at authorized Chevrolet dealers, whether you are the first owner or bought the car used.