2009 Can-AM Spyder GS recalls and problems

The 2009 Can-AM Spyder GS has 2 safety recalls and 14 owner complaints filed with NHTSA. Recall repairs are free at any Can-AM dealer.

Recalls

Complaints

Crashes / fires

1 / 3

Injuries / deaths

2 / 0

Recalls may cover only some 2009 Can-AM Spyder GS vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2009 Can-AM Spyder GS recalls

Recall 12V-581: Fuel System, Gasoline

Reported Dec 12, 2012 · 9,600 vehicles affected · Bombardier Recreational Products Inc.

Problem: Bombardier Recreational Products Inc. (BRP) is recalling certain model year 2008-2009 Can-Am Spyder GS and model year 2010 Can-AM Spyder RS vehicles. Fuel vapors may exit the fuel vapor canister vent hose in the enclosed engine compartment.

Risk: Fuel vapors in the presence of an ignition source could result in a fire and personal injury.

Fix: BRP will notify owners, and dealers will inspect the fuel vapor canister vent hose and replace and re-route it, as necessary, free of charge. The safety recall began on December 26, 2012. Owners may contact BRP AT 1-888-638-5397.

Recall 12V-582: Fuel System, Gasoline

Reported Dec 12, 2012 · 33,700 vehicles affected · Bombardier Recreational Products Inc.

Problem: Bombardier Recreational Products Inc. (BRP) is recalling certain model year 2008-2012 Can-Am Spyder GS, RS, and RT series vehicles. The fuel cap may not fit onto the fuel tank filler neck, preventing it from sealing properly.

Risk: If the fuel cap does not seal properly, it may leak fuel vapors. Fuel vapors in the presence of an ignition source could result in a fire and personal injury.

Fix: BRP will notify owners and send them a replacement fuel cap, free of charge. The safety recall is expected to begin in mid-January 2013. Owners may contact BRP AT 1-888-638-5397.

2009 Can-AM Spyder GS problems reported by owners

Problem area	Reports
Steering	7
Engine and Engine Cooling	2
Unknown or Other	2
Power Train	1
Vehicle Speed Control	1
Electrical System	1
Engine	1
Service Brakes	1
Exterior Lighting	1

Most reported parts

Power Train › Automatic Transmission — 1

Typical mileage at the time of the problem: 3,500 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2009 Can-AM Spyder GS complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Steering · at 11,000 miles · reported Sep 12, 2015

Bike went in (Limp mode) because dynamicpower steering(Dps) unit needs to be replaced, can AM/brp had a recall of the (Dps) units on september 7,2010, however is now refusing to repair my can-AM pursuant to said recall.

Electrical System · at 15,000 miles · reported Oct 1, 2014

I refueled my motorcycle, as I was leaving I noticed my legs get hot. I did not pay it much mind until there was an absurd amount of pain then I looked down and I seen that my motorcycle was on fire. I then pulled over and called 911 for assistance and be transported to the hospital to get treated for my burns. My motorcycle was destroyed. The electronics were fried, the plastics were melted and it stunk of gasoline. I also taken pictures of the burns to my leg and the motorcycle.

Engine and Engine Cooling · at 2,000 miles · reported Sep 7, 2010

The contact owns a 2009 can-AM spyder gs. The contact stated that the while driving at any speed the vehicle stalled. The vehicle was towed to the dealer four times. They have been unable to duplicate the failure. The owner became aware of a recall but she never received a letter even though her VIN was included. The vehicle was not repaired. The failure mileage was approximately 2000. The VIN was unknown.

Steering · at 4,674 miles · reported May 26, 2010

The contact owns a 2009 can-AM spyder. The contact stated that while driving at 25 MPH on may 26, 2010, the vehicle would swerve suddenly causing the contact to lose control. The contact had to slowly apply the brakes to gain control. The vehicle had previously been repaired for recall 09v162000 (Steering) in august 2009 but the failure occurred again. The dealer, when contacted, advised the contact to take the vehicle in for diagnosis. The current and failure mileages were 4,674.

Vehicle Speed Control · at 512 miles · reported Apr 30, 2010

While traveling at less than 15mph, the engine continued to accelerate out of control. Brakes were applied but finally gave out vehicle was not able to get stopped. Vehicle with driver jumped a curb went out of control hit another vehicle. Throttle was check and appeared to be operation ok. Suspect the vehicle software as cause. Vehicle was serviced prior to incident and reportedly checked out ok. Computer was down loaded and showed high RPM and acceleration up to the moment of impact.

Other Can-AM Spyder GS years

20092008

Compare all Can-AM Spyder GS years · All Can-AM models

Frequently asked questions

Does the 2009 Can-AM Spyder GS have any recalls?

Yes — NHTSA lists 2 recalls for the 2009 Can-AM Spyder GS: 12V-581 (fuel system, gasoline), 12V-582 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2009 Can-AM Spyder GS?

Owners report steering problems most often (7 reports), followed by engine and engine cooling (2). The typical mileage when problems were reported is about 3,500 miles.

Are Can-AM recall repairs free?

Yes. Safety recall repairs are free at authorized Can-AM dealers, whether you are the first owner or bought the car used.