Home › BMW › R1200 RT › 2011

2011 BMW R1200 RT recalls and problems

The 2011 BMW R1200 RT has 1 safety recall and 10 owner complaints filed with NHTSA. Recall repairs are free at any BMW dealer.

Recalls
1
Complaints
10
Crashes / fires
0 / 0
Injuries / deaths
0 / 0

Recalls may cover only some 2011 BMW R1200 RT vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2011 BMW R1200 RT recalls

Recall 20V-471: Fuel System, Gasoline

Reported Aug 10, 2020 · 16,926 vehicles affected · BMW of North America, LLC

Problem: BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Fix: BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.

2011 BMW R1200 RT problems reported by owners

Problem areaReports
Fuel/Propulsion System6
Electrical System2
Exterior Lighting1
Vehicle Speed Control1
Power Train1
Engine1
Unknown or Other1

Typical mileage at the time of the problem: 18,818 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2011 BMW R1200 RT complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Fuel/Propulsion System · reported Jul 23, 2019
Gasoline leak from fuel pump flange. Noticed a puddle of gasoline after a ride last week. During the ride , there was a strong smell of gasoline. This is a very dangerous situation. Bmw are you listening ? The puddle was on the left side of the bike when riding ( Right side if you are facing the bike) this was fixed during a recall campaign in 2014 but its back again. This indicates a substandard used during recall fix. Its bmw's responsibility to have this addressed and fixed asap.
Fuel/Propulsion System · reported Jul 23, 2019
Fuel pump output flange cracked, resulting in fuel leaking down the side of the bike and onto hot components while riding. This issue has already been the subject of a bmw recall - but apparently the "inspect and reinforce" solution isn't really adequate long-term. This pump had been inspected and reinforced - and the flange still cracked and caused a dangerous fuel leak with the potential for bodily injury or worse. Attached picture. Top shows before ignition is switched on. Bottom is after ignition is on.
Fuel/Propulsion System · at 29,750 miles · reported May 3, 2019
My 2011 bmw r1200rt had a recall repair performed in 2015 to address a fuel leak issue at the fuel pump flange. The dealer did not replace the fuel pump assembly but did a repair which involved installation of a reinforcement ring on the fuel pump flange which was cracking and leaking fuel under pressure. In march of 2019 the area that was repaired on the fuel pump developed a fuel leak causing gasoline to leak under pressure and leak down onto the engine which could have caught fire. My left boot and left lower pant leg got wet with gasoline. Bmw should have fixed this problem properly with a…
Fuel/Propulsion System · at 18,400 miles · reported Mar 11, 2019
When starting the vehicle gas begins to leak out of tank on left side of vehicle. Leak will continue until vehicle is shut off
Fuel/Propulsion System · at 31,588 miles · reported Aug 28, 2017
On august 23, 2017, I started my motorcycle and left my home for a ride. A short time into the ride I noticed the smell of gasoline. I found a place to pull over to check out the issue. When I stopped I saw gasoline flowing down on the left side of the motorcycle onto the ground, just past the exhaust pipe and onto my left riding boot. I immediately returned home slowly to check out the leak. When I removed the upper left side of the motorcycle, I saw gasoline puddling around the top of the fuel pump. A metal ring had been installed over the plastic quick connector on top of the fuel pump on a…

Other BMW R1200 RT years

2011201020092008200720062005

Compare all BMW R1200 RT years · All BMW models

Frequently asked questions

Does the 2011 BMW R1200 RT have any recalls?

Yes — NHTSA lists 1 recall for the 2011 BMW R1200 RT: 20V-471 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2011 BMW R1200 RT?

Owners report fuel/propulsion system problems most often (6 reports), followed by electrical system (2). The typical mileage when problems were reported is about 18,818 miles.

Are BMW recall repairs free?

Yes. Safety recall repairs are free at authorized BMW dealers, whether you are the first owner or bought the car used.