2004 BMW R1150 RT recalls and problems

The 2004 BMW R1150 RT has 1 safety recall and 18 owner complaints filed with NHTSA. Recall repairs are free at any BMW dealer.

Recalls

Complaints

Crashes / fires

1 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2004 BMW R1150 RT vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2004 BMW R1150 RT recalls

Recall 04V-304: Service Brakes, Hydraulic

Reported Jun 23, 2004 · 181 vehicles affected · BAYERISCHE MOTOREN WERKE

Problem: On certain motorcycles, an incorrect sealing ring was mounted to the piston of the rear brake master cylinder.

Risk: If only the rear brake were applied during riding, insufficient braking pressure would be available to slow the motorcycle, which could increase the risk of a crash.

Fix: Dealers will replace the rear brake master cylinder. The recall began july 16, 2004. Owners should contact bmw at 1-800-831-1117.

2004 BMW R1150 RT problems reported by owners

Problem area	Reports
Power Train	13
Fuel System, Gasoline	2
Fuel/Propulsion System	2
Tires	1
Service Brakes	1

Most reported parts

Power Train › Clutch Assembly — 1
Power Train › Manual Transmission — 1
Power Train › Driveline — 1
Power Train › Driveline › Differential Unit — 1

Typical mileage at the time of the problem: 33,095 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2004 BMW R1150 RT complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Service Brakes · reported Jun 15, 2022

Total brake failure .I could not stop the motorcycle.I went rite through an intersection,thank god there was no vehicles driving through the intersection at the same time.

Fuel/Propulsion System · reported Jun 11, 2017

My motorcycle kept losing fuel. I never leave it low on gas, but on numerous occasions went to ride it and the tank was empty. Since then I found a youtube video showing how to replace what bmw never should have installed, saying this is common in ca because bmw did not use metal quick disconnects on the fuel lines; our gas eats the plastic. At least 10 gallons of gas disappeared over 4 months last summer. This is a major fire hazard and I AM lucky to be alive, I guess. It also is not cheap to fix. The parts are around $100. Bmw should fix this, or pay for parts so I can do it.

Fuel/Propulsion System · at 14,000 miles · reported Jul 24, 2013

Fuel line quick disconnects on both supply and return failed causing fuel leak on to engine and exhaust. Extreme fire potential. Quick disconnect seals and components are insufficient to handle exposure to raw fuel, it is a poor design and bmwna should recall r1150rt's due to this failure and fire risk.

Power Train · at 33,095 miles · reported Jul 18, 2012

The rear tire became oil covered and slick because of a failed oil seal in the final drive. The oil seal had failed as results of the final drive bearing failure. These failures caused an unsafe condition as there was excessive movement in the rear wheel and the rear tire was oil soaked from the seal failure. The failure gave little advanced warning as road and tire noise changes and sound similar. I have had two final drive failures on the same motorcycle, the first 06/04/2006 at 33,095 miles at 25 MPH and the second 07/13/2012 at 74,341 miles at 65 MPH on the interstate system.

Power Train · at 17,000 miles · reported Jul 10, 2012

The contact owns a 2004 bmw r1150rt motorcycle. The contact stated that the final drive assembly failed. The failure caused the rear end to severely knock. The contact stated that oil spilled out from the vehicle as well. The contact was told by the dealer that there was a 3-6 month back order on the part that was needed to correct the failure. The vehicle was not repaired. The failure and the current mileage was 17,000.

Other BMW R1150 RT years

No other model years have data.

Compare all BMW R1150 RT years · All BMW models

Frequently asked questions

Does the 2004 BMW R1150 RT have any recalls?

Yes — NHTSA lists 1 recall for the 2004 BMW R1150 RT: 04V-304 (service brakes, hydraulic). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2004 BMW R1150 RT?

Owners report power train problems most often (13 reports), followed by fuel system, gasoline (2). The typical mileage when problems were reported is about 33,095 miles.

Are BMW recall repairs free?

Yes. Safety recall repairs are free at authorized BMW dealers, whether you are the first owner or bought the car used.