2002 BMW R Series recalls and problems

The 2002 BMW R Series has 1 safety recall and 8 owner complaints filed with NHTSA. Recall repairs are free at any BMW dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2002 BMW R Series vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2002 BMW R Series recalls

Recall 04V-028: Fuel System, Gasoline

Reported Jan 15, 2004 · 39,000 vehicles affected · BAYERISCHE MOTOREN WERKE

Problem: On certain motorcycles, the o-ring in fuel line quick-disconnect coupling could become damaged and lead to a fuel leak. There is also a problem involving crimp-type hose clamps, which can result in a fuel leak.

Risk: Fuel leakage in the presence of an ignition source could result in a fire.

Fix: Dealers will inspect and, if necessary, adjust all crimp-type hose clamps. Also, all fuel line quick-disconnect couplings will be inspected. If a leak is detected, the quick-disconnect o-ring will be replaced. If damaged, the coupling will be replaced. Owner notification began on april 30, 2004. Owners should contact bmw at 1-800-831-1117.

2002 BMW R Series problems reported by owners

Problem area	Reports
Fuel System, Gasoline	3
Power Train	3
Structure	1
Service Brakes, Hydraulic	1

Most reported parts

Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, and Fittings — 2
Power Train › Axle Assembly — 1
Structure › Motorcycle › Kickstand/Center Stand — 1

Typical mileage at the time of the problem: 42,300 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2002 BMW R Series complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Power Train · at 28,900 miles · reported Feb 5, 2012

Operating under normal driving condition at speed below 40 MPH. Vehicle loss all power from engine to transmission. Engine still operates and revs normally, but no engine power is transferred to transmission. Transmission still shift proper into each gear in the gearbox. Vehicle towed to main line bmw motorcycle, diagnosed with failure of clutch and drive shaft spline interface. Clutch and transmission input shaft replaced, transmission rebuilt under vehicle factory warranty (2 year/30,000 mi.).

Service Brakes, Hydraulic · at 43,000 miles · reported Jun 30, 2011

Earlier in the week the ABS failure lights came on and then the brakes stopped working effectively. There is a backup "residual braking" of about 15%. I survived because I was not in traffic and did not need a serious stop. I had it "fixed" at the dealer on saturday. The lights were out and the brakes worked for about 4 on off cycles. Then they failed again driving down the road. It has been intermittent since. I then researched this problem on the internet and found it is rampant. People have been permanently disabled. Motorcycles have crashed over and over. Bmw ignores it and wants over…

Structure · at 45,000 miles · reported Oct 28, 2010

The contact owns a 2002 bmw r1150rt.. While starting the motorcycle, the kickstand bent and it fell over. The motorcycle was taken home where the contact repaired it himself. The failure mileage was 45,000 and the current mileage was 51,000. Updated 12/20/10 the consumer stated he did not receive any paper work to fill out. Updated 12/27/10 updated 01/13/11 updated 01/27/11

Fuel System, Gasoline · at 20,600 miles · reported Aug 2, 2010

The contact owns a 2002 bmw r1150rt motorcycle. While driving approximately 70 MPH, the contact noticed fuel was leaking from the connecting sleeve to the fluid line. In addition, fuel began leaking onto the hot cylinder. This was the second instance of the failure. The vehicle was not taken to the dealer for diagnostic testing or repairs. The failure mileage was 20,600 and the current mileage is 25,300. Updated 10/21/10. Updated 10/26/10

Power Train · at 43,000 miles · reported Dec 24, 2009

Clutch to transmission input shaft splines failed on my 2002 bmw r1150rt motorcycle. Sudden loss of power due to failure of the splines which connect the clutch plate to the transmission input shaft. Fortunately I was on a side street which wasn't busy and near home. No accident resulted due to location where failure occurred.

Other BMW R Series years

2007 2005 200420022001 2000

Compare all BMW R Series years · All BMW models

Frequently asked questions

Does the 2002 BMW R Series have any recalls?

Yes — NHTSA lists 1 recall for the 2002 BMW R Series: 04V-028 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2002 BMW R Series?

Owners report fuel system, gasoline problems most often (3 reports), followed by power train (3). The typical mileage when problems were reported is about 42,300 miles.

Are BMW recall repairs free?

Yes. Safety recall repairs are free at authorized BMW dealers, whether you are the first owner or bought the car used.