2005 BMW K1200 LT recalls and problems

The 2005 BMW K1200 LT has 2 safety recalls and 19 owner complaints filed with NHTSA. Recall repairs are free at any BMW dealer.

Recalls

Complaints

Crashes / fires

3 / 0

Injuries / deaths

3 / 0

Recalls may cover only some 2005 BMW K1200 LT vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2005 BMW K1200 LT recalls

Recall 04V-438: Fuel System, Gasoline

Reported Sep 9, 2004 · 380 vehicles affected · BMW OF NORTH AMERICA, LLC

Problem: On certain motorcycles, at lower temperatures, wiring within the anti-theft control unit may press against the fuel pump relay. The fuel pump relay contacts could open, interrupting the fuel supply to the engine, resulting in stalling.

Risk: If stalling were to occur, the driver would be unable to maintain speed or accelerate, increasing the risk of a crash.

Fix: Dealers will inspect and, if necessary, replace the anti-theft control unit. The recall began october 4, 2004. Customers should contact bmw at 1-800-831-1117.

Recall 04V-304: Service Brakes, Hydraulic

Reported Jun 23, 2004 · 181 vehicles affected · BAYERISCHE MOTOREN WERKE

Problem: On certain motorcycles, an incorrect sealing ring was mounted to the piston of the rear brake master cylinder.

Risk: If only the rear brake were applied during riding, insufficient braking pressure would be available to slow the motorcycle, which could increase the risk of a crash.

Fix: Dealers will replace the rear brake master cylinder. The recall began july 16, 2004. Owners should contact bmw at 1-800-831-1117.

2005 BMW K1200 LT problems reported by owners

Problem area	Reports
Fuel System, Gasoline	9
Power Train	4
Service Brakes, Hydraulic	3
Suspension	3
Vehicle Speed Control	1
Steering	1
Service Brakes	1

Most reported parts

Power Train › Driveline — 3
Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip › Control Unit/Module — 1
Service Brakes, Hydraulic › Power Assist — 1

Typical mileage at the time of the problem: 23,200 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2005 BMW K1200 LT complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Suspension · at 20,000 miles · reported Mar 8, 2015

While riding in to a left handed corner the front right front leg broke standing the motorcycle straight up and sending me and the bike into the guardrail causing a crash that I was lucky to walk away from.

Service Brakes · at 45,000 miles · reported Mar 6, 2013

The contact owns a 2005 bmw k1200lt. The contact stated that while driving approximately 20 to 25 MPH and decelerating, the brakes seized which caused the contact to crash. The contact received injuries to his left leg and was transported to the hospital. The vehicle was later taken to the dealer. After inspection, they advised him that there was a failure but were unaware of code reading. The manufacturer was contacted and they advised him that they would send the information to germany. The failure and current mileages were approximately 45,000.

Power Train · at 23,200 miles · reported May 3, 2012

Final drive failure. This is the same failure as described in odi no. 10439549, and currently being investigated under campaign dp12001.

Steering · at 62,805 miles · reported Feb 6, 2012

The upper threaded portion of the shaft of the front suspension ball joint broke off, which is the connection point from the leading link to the front fork bridge, an integral part of bmw's telelever front suspension. Loss of this connection point allows the front forks to move front to rear causing dangerous loss of steering control. Normal operation of the telelever suspension exerts forces which are longitudinal along the ball joint shaft. The ball joint shaft is not subject to sideways shear force, so the shaft should not have broken under normal wear and tear under any circumstances. The…

Fuel System, Gasoline · at 14,839 miles · reported Nov 28, 2011

The contact owns a 2005 bmw k1200lt motorcycle. The contact stated that the vehicle was leaking gasoline. The vehicle was taken to a local mechanic who diagnosed that the fuel line couplers were fractured and needed to be replaced. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure and the current mileage was 14,839.

Other BMW K1200 LT years

No other model years have data.

Compare all BMW K1200 LT years · All BMW models

Frequently asked questions

Does the 2005 BMW K1200 LT have any recalls?

Yes — NHTSA lists 2 recalls for the 2005 BMW K1200 LT: 04V-438 (fuel system, gasoline), 04V-304 (service brakes, hydraulic). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2005 BMW K1200 LT?

Owners report fuel system, gasoline problems most often (9 reports), followed by power train (4). The typical mileage when problems were reported is about 23,200 miles.

Are BMW recall repairs free?

Yes. Safety recall repairs are free at authorized BMW dealers, whether you are the first owner or bought the car used.