2007 BMW F800 ST recalls and problems

The 2007 BMW F800 ST has 2 safety recalls and 8 owner complaints filed with NHTSA. Recall repairs are free at any BMW dealer.

Recalls

Complaints

Crashes / fires

0 / 1

Injuries / deaths

0 / 0

Recalls may cover only some 2007 BMW F800 ST vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2007 BMW F800 ST recalls

Recall 08V-342: Steering

Reported Jul 25, 2008 · 428 vehicles affected · BMW OF NORTH AMERICA, LLC

Problem: Bmw is recalling 428 my 2007 f800 s, f800 st, r1200 r, k1200 s, k1200 r, k1200 r sport, and k1200 gt motorcycles. It is possible for the coating to separate from the inside face of the steering damper housing. If this happened, the coating could partially clog the oil bores within the damper.

Risk: If this occurred, the steering damper could become stiff increasing the risk of a crash.

Fix: Dealers will replace the steering damper free of charge. The recall began during september 2008. Owners may contact bmw at 1-800-831-1117.

Recall 08V-241: Fuel System, Gasoline

Reported Jun 2, 2008 · 1,980 vehicles affected · BMW OF NORTH AMERICA, LLC

Problem: Bmw is recalling 1,980 my 2007-2008 f800 s and f800 st motorcycles. Due to the routing of the fuel tank breather hose, pressure equalization inside the fuel tank is possible only to a limited extent. Consequently, at high ambient temperatures, the fuel tank can deform. If this happened at the point where the fuel tank is shaped to provide clearance for the rear wheel, then, in combination with a large payload, the bottom of the tank could rub against the rear wheel.

Risk: If this occurred, it is possible that a leak could develop in the tank. Fuel leakage in the presence of an ignition source could result in a fire.

Fix: Dealers will reroute the fuel tank breather hose. The recall began during august 2008. Owners may contact bmw at 1-800-331-1117.

2007 BMW F800 ST problems reported by owners

Problem area	Reports
Fuel System, Gasoline	2
Suspension	2
Electrical System	2
Service Brakes, Hydraulic	1
Wheels	1
Power Train	1
Structure	1
Fuel/Propulsion System	1

Typical mileage at the time of the problem: 12,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2007 BMW F800 ST complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Suspension · at 18,000 miles · reported Mar 18, 2013

The contact owns a 2007 bmw f800 st. The contact stated that while driving approximately 40 MPH, he noticed a chirping sound coming from the rear. The vehicle was taken to the dealer for diagnosis. The technician stated the rear wheel bearing would have to be replaced as well as the rear axle sustained damage due to the rear bearing failure. The manufacturer was not made aware of failure. The vehicle was repaired. The approximate failure mileage was 18,000.

Structure · at 7,100 miles · reported Aug 11, 2012

The plastic mounting plate holding the fuel pump and fuel gauge sending unit developed a hairline crack. This crack allowed fuel to escape from the tank uncontrolled, which could cause a fire. The motorcycle was parked in the garage, where a gas water heater nearby could have ignited the fumes. This crack was not caused by any contact or pressure from any other component of the motorcycle as it is protected beneath the seat and a substantial recess in the fuel tank. The local dealership admitted that they replace as many as two of these cracked mounting plates per month. This condition was not…

Electrical System · at 9,500 miles · reported Jul 5, 2012

During commuting all lights off, no turn, no stop lights, the bmw canbus switch off computer, speedometr, tachometr and ABS stop working. Battery supply/feed only engine, after few minutes engine stops. Burnt smoke and odor come from alternator.

Power Train · at 16,000 miles · reported May 30, 2012

During use last weekend I noticed the drive belt riding abnormally on the rear drive pulley. I disassembled the rear drive on the motorcycle today and found the bearings and rear wheel support shaft in need of complete replacement. Investigation on the web readily reveals dozens of threads on this subject, with results of failures including complete wheel lockup at highway speed. Simply do a search using "bmw f800 bearing failure" and primary results encountered will be for the rear wheel bearings - several pages of them. The rear support axle was redesigned with new shipments in mid 2009…

Wheels · at 29,100 miles · reported Sep 10, 2011

The rear wheel bearing seized causing a catastrophic wheel separation from the pulley and belt drive. I was told by bmw motorcycles of escondido, ca that the insides appeared to have "welded together" with the bearing and shaft "rusting together." I was told that this had never been an issue with other bikes that they have seen. However, numerous online forums indicate that this is a widely known issue.

Other BMW F800 ST years

20082007

Compare all BMW F800 ST years · All BMW models

Frequently asked questions

Does the 2007 BMW F800 ST have any recalls?

Yes — NHTSA lists 2 recalls for the 2007 BMW F800 ST: 08V-342 (steering), 08V-241 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2007 BMW F800 ST?

Owners report fuel system, gasoline problems most often (2 reports), followed by suspension (2). The typical mileage when problems were reported is about 12,000 miles.

Are BMW recall repairs free?

Yes. Safety recall repairs are free at authorized BMW dealers, whether you are the first owner or bought the car used.