2007 BMW F800 S recalls and problems

The 2007 BMW F800 S has 2 safety recalls and 4 owner complaints filed with NHTSA. Recall repairs are free at any BMW dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2007 BMW F800 S vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2007 BMW F800 S recalls

Recall 08V-342: Steering

Reported Jul 25, 2008 · 428 vehicles affected · BMW OF NORTH AMERICA, LLC

Problem: Bmw is recalling 428 my 2007 f800 s, f800 st, r1200 r, k1200 s, k1200 r, k1200 r sport, and k1200 gt motorcycles. It is possible for the coating to separate from the inside face of the steering damper housing. If this happened, the coating could partially clog the oil bores within the damper.

Risk: If this occurred, the steering damper could become stiff increasing the risk of a crash.

Fix: Dealers will replace the steering damper free of charge. The recall began during september 2008. Owners may contact bmw at 1-800-831-1117.

Recall 08V-241: Fuel System, Gasoline

Reported Jun 2, 2008 · 1,980 vehicles affected · BMW OF NORTH AMERICA, LLC

Problem: Bmw is recalling 1,980 my 2007-2008 f800 s and f800 st motorcycles. Due to the routing of the fuel tank breather hose, pressure equalization inside the fuel tank is possible only to a limited extent. Consequently, at high ambient temperatures, the fuel tank can deform. If this happened at the point where the fuel tank is shaped to provide clearance for the rear wheel, then, in combination with a large payload, the bottom of the tank could rub against the rear wheel.

Risk: If this occurred, it is possible that a leak could develop in the tank. Fuel leakage in the presence of an ignition source could result in a fire.

Fix: Dealers will reroute the fuel tank breather hose. The recall began during august 2008. Owners may contact bmw at 1-800-331-1117.

2007 BMW F800 S problems reported by owners

Problem area	Reports
Engine and Engine Cooling	3
Fuel System, Gasoline	1
Power Train	1

Most reported parts

Engine and Engine Cooling › Engine — 1
Power Train › Driveline — 1

Typical mileage at the time of the problem: 13,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2007 BMW F800 S complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Engine and Engine Cooling · at 13,000 miles · reported Jan 16, 2012

The motor on my 2007 bmw f800s started knocking in the spring of 2011. This is approx 6 months after the warranty expired. I brought the bike in to the dealer. They told me it was fine. This process was repeated two more times. Finally the engine was removed and diagnosed. The dealer found complete piston failure (Piston slap). The piston skirt was grinding into the cylinder wall. Both the pistons and barrels need to be replaced. The cost of the repair is more than the value of the bike. Based on visual evidence of the damage I have found at least one engineer that stated it clearly started…

Power Train · at 45,000 miles · reported Dec 4, 2010

I AM writing you to please urge investigation of all bmw f800s and f800st motorcycles. I have been researching a problem with these motorcycles since I purchased my 2007 f800s for the first time in june of 2009. Soon after I purchased the motorcycle, my rear wheel bearing failed causing a severe wobble. The dealer replaced the bearing and eccentric axle which they say was "improved" with a harder steel in the axle. Fast forward just over a year later (12/2/10) my rear wheel bearing failed again. I took it back to the same exact dealer and they have not made any other improvements to the design…

Engine and Engine Cooling · at 1,780 miles · reported Nov 18, 2010

Bmw motorcycle: engine stalling, dying, at idle or during slow gear change, downshift, after engine is fully warmed up, ongoing problem even after dealer tried to fix. Several similar reports on bmw riders forum. Causes unsafe operation if stalling on turn, or at intersection. Have been able to avoid crash and get off highway so far. Continues to stall intermittently. No apparent rhyme or reason, but always after bike has been running for several minutes, fully warmed up. Will always re-start but will die again of not held above idle. Very tricky after stop at intersection or on a turn. Dealer…

Engine and Engine Cooling · at 333 miles · reported Aug 9, 2009

Sporadic engine stall while downshifting at both high and low speeds. Common complaint, but no recall issued. Engine stalls while in motion, could lead to serious injury or death.

Other BMW F800 S years

20082007

Compare all BMW F800 S years · All BMW models

Frequently asked questions

Does the 2007 BMW F800 S have any recalls?

Yes — NHTSA lists 2 recalls for the 2007 BMW F800 S: 08V-342 (steering), 08V-241 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2007 BMW F800 S?

Owners report engine and engine cooling problems most often (3 reports), followed by fuel system, gasoline (1). The typical mileage when problems were reported is about 13,000 miles.

Are BMW recall repairs free?

Yes. Safety recall repairs are free at authorized BMW dealers, whether you are the first owner or bought the car used.