2005 Bigdog Mastiff recalls and problems
The 2005 Bigdog Mastiff has 8 safety recalls and 1 owner complaint filed with NHTSA. Recall repairs are free at any Bigdog dealer.
Recalls may cover only some 2005 Bigdog Mastiff vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2005 Bigdog Mastiff recalls
Recall 07V-580: Structure
Problem: On certain motorcycles, the rear fender strut attaching bolts can fail allowing the rear fender to detach from the motorcycle.
Risk: This could occur without prior warning and could result in an injury or a crash.
Fix: Dealers will remove existing strut bolts and replace with higher tensile strength attaching bolts and updated washers. Higher torque values will be observed when installing the replacement fasteners. The recall began on january 21, 2008. Owners may contact big dog at 316-267-9121.
Recall 07V-356: Electrical System
Problem: On certain motorcycles, a warped bus bar within the voltage regulator can cause a short circuit.
Risk: This could possibly result in a fire.
Fix: Dealers will replace the existing circuit breaker located between the voltage regulator positive battery lead (B+ lead) and the positive battery terminal with an alternative circuit protection device that will prevent a thermal event if there is a short to ground. The recall began on october 1, 2007. Owners may contact big dog at 1-316-219-9129 or email to customer.service@bigdogmotorcycles.com.
Recall 06V-389: Structure
Problem: On certain motorcycles, the long pivot bolt may bend or break during normal operation of the motorcycle.
Risk: This could potentially cause the rear fender to abrade against the rear tire while the motorcycle is being driven. This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will replace the long pivot bolt and, if necessary, straighten the rear frame side panel. The short left side pivot bolt and pivot shaft may also be replaced free of charge. The recall began on november 1, 2006. Owners may contact big dog at 316-267-9121.
Recall 06V-305: Electrical System
Problem: On certain motorcycles, the electronic harness control (Ehc) module can fail resulting in a total shut down of the vehicle's electronic power.
Risk: This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will replace the ehc modules free of charge. The recall began on september 19, 2006. Owners may contact big dog at 316-267-9121.
Recall 06V-301: Electrical System
Problem: On certain motorcycles, the ignition modules are oriented within the battery tray in a way that makes the ignition module susceptible to vibration.
Risk: This susceptibility to vibration may contribute to a stalling condition that could occur without any prior warning and result in a crash.
Fix: Dealers will install a new ignition module mounting system free of charge. The recall began on august 25, 2006. Owners may contact big dog at 316-267-9121.
Recall 06V-019: Structure
Problem: On certain motorcycles, the kickstand spring may stretch and detach from the mounting bracket or the kickstand.
Risk: This will allow the kickstand to deploy into the extended position and cause a crash.
Fix: Dealers will install a new kickstand spring free of charge. The recall began on february 17, 2006. Owners may contact big dog at 316-267-9121.
Recall 05V-432: Wheels
Problem: On certain motorcycles, the rear wheel hub bolts could loosen and back out allowing the hub and brake rotor to detach from the wheel with an associated loss of stopping power.
Risk: This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will remove, clean and reattach the rear hub bolts free of charge. The recall began on october 14, 2005. Owners may contact big dog at 1-312-267-9121.
Recall 05V-149: Power Train
Problem: On certain motorcycles, the primary drive sprocket nut may back off the engine main shaft.
Risk: This could cause the primary drive to lock up and cause a crash. This condition could occur without any prior warning.
Fix: Dealers will inspect and replace the drive sprocket nut free of charge. The recall began on may 13, 2005. Owners may contact big dog at 316-267-9121.
2005 Bigdog Mastiff problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Engine and Engine Cooling | 1 | |
| Electrical System | 1 |
Most reported parts
- Electrical System › Alternator/Generator/Regulator — 1
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Bigdog Mastiff complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Bigdog Mastiff years
Frequently asked questions
Does the 2005 Bigdog Mastiff have any recalls?
Yes — NHTSA lists 8 recalls for the 2005 Bigdog Mastiff: 07V-580 (structure), 07V-356 (electrical system), 06V-389 (structure), 06V-305 (electrical system), 06V-301 (electrical system) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2005 Bigdog Mastiff?
Owners report engine and engine cooling problems most often (1 reports), followed by electrical system (1).
Are Bigdog recall repairs free?
Yes. Safety recall repairs are free at authorized Bigdog dealers, whether you are the first owner or bought the car used.