2003 Audi Allroad recalls and problems

The 2003 Audi Allroad has 3 safety recalls and 14 owner complaints filed with NHTSA. Recall repairs are free at any Audi dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2003 Audi Allroad vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2003 Audi Allroad recalls

Recall 08V-157: Fuel System, Gasoline

Reported Apr 8, 2008 · 68,240 vehicles affected · VOLKSWAGEN OF AMERICA, INC

Problem: Volkswagen is recalling 68,240 my 2001-2004 audi a6 quattro vehicles equipped with 2.7l, 2.8l, or 3.0l engines and my 2001-2005 allroad quattro vehicles equipped with 2.7l or 4.2l engines. The aging of the plastic material in the fuel tank rollover valve combined with bending stress from the aluminum ventilation line to the rollover valve nipple may lead to cracking of the nipple. If this happens, a fuel leak may result.

Risk: A fuel leak in the presence of an ignition source could lead to a vehicle fire.

Fix: Dealers will reinforce the nipple on the rollover valve to prevent leakage or repair the cracking at the nipple. The recall began on june 27, 2008. Owners may contact audi at 1-800-822-2834.

Recall 06V-198: Electrical System

Reported Jun 5, 2006 · 70,512 vehicles affected · VOLKSWAGEN OF AMERICA, INC

Problem: On certain passenger vehicles equipped with halogen low beam headlights, certain connector pins in the headlight switch connector come into contact with each other causing a short circuit. Note: vehicles with xenon low beam headlights are not affected because the circuit in these vehicles contains a fuse, which precludes excessive current flow in the case of a short circuit. Audi s6 and s6 avant vehicles are all equipped with xenon low beam headlights and, therefore, are not longer affected by this recall.

Risk: This condition could lead to overheating or fire.

Fix: Dealers will reroute the wiring harness by installing a jumper wiring harness. The recall began on december 16, 2006. Owners may contact audi at 1-800-822-2834.

Recall 04V-133: Electrical System

Reported Mar 18, 2004 · 172,866 vehicles affected · VOLKSWAGEN OF AMERICA, INC

Problem: On certain passenger vehicles, if a driver's knees push against the knee bolster (Crash element) located under the dashboard, it can contact the headlight switch wiring harness, and an electrical short could occur.

Risk: A fire could originate in the left dashboard area.

Fix: Dealers will install a protective covering on the knee bolster (Crash element). In addition, the wiring harness as well as the felt protector on the left side of the dashboard carrier will be checked, and replaced if necessary. The recall began on july 26, 2004. Owners should contact audi at 1-800-822-2834.

2003 Audi Allroad problems reported by owners

Problem area	Reports
Electrical System	5
Power Train	4
Structure	2
Tires	1
Suspension	1
Engine and Engine Cooling	1
Seat Belts	1
Wheels	1
Fuel/Propulsion System	1
Air Bags	1

Most reported parts

Electrical System › Instrument Cluster/Panel — 3
Power Train › Automatic Transmission — 1
Tires › Tread/Belt — 1
Electrical System › Ignition — 1
Suspension › Front — 1
Seat Belts › Front — 1
Air Bags › Frontal › Driver Clockspring/Spiral Cassette — 1
Structure › Body — 1

Typical mileage at the time of the problem: 94,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2003 Audi Allroad complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Structure · reported Dec 18, 2021

During recent heavy rains, all of a sudden the car's transmission that had been working fine, after having been parked briefly pointing slightly down hill, no longer functioned properly, and had apparently gone into "LIMP Mode". after talking with Mechanics and doing research, we checked the carpet areas and determined and documented the car's interior was very wet, both in front and in the rear areas, with evident moisture and corrosion under the battery and cabin air filter areas and rear wheel well area. The Transmission no longer shifts properly and the car is not able to be safely driven.…

Air Bags · at 135,000 miles · reported Feb 18, 2021

The contact owns a 2003 audi allroad. The contact stated that the air bag warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with needing clock spring to be replaced. The vehicle was repaired however, the failure persisted. The manufacturer was not informed of the failure. The failure mileage was approximately 135,000.

Fuel/Propulsion System · at 167,000 miles · reported Sep 18, 2015

The fuel tank has developed a leak on its own. I filled my car the thursday september 3, 2015. On september 8, 2015 the fuel gauge was down a quarter tank. I smelled gas outside of the car. My mechanic tells me the leak is at a plastic welded nub on the right side of the tank.this is a plastic fuel tank. If I fill the tank above the halfway mark this is when the tank leaks. The car is going in for service on monday for a fuel tank replacement. I have opened case number 150699218 with audi corporate. They wanted me to allow them to tow the car to a dealership and let the dealer make a…

Engine and Engine Cooling · at 106,000 miles · reported Oct 27, 2010

Engine overheat, automatic fan fails to go on, the engine spill fume to a blinding level when it begins to come from beneath the hood . Heating and cooling systems shut down actions taken by the dealership service department include new water pump new radiator new air conditioning pump did not bring any solution.

Suspension · at 94,000 miles · reported Feb 17, 2010

Air suspension for audi allroad failed. All air was vented out of the front suspension without warning resulting in loss of vehicle control when car hit a bump/dip in the road. Car seemed to bounce off the front tires and was a violent compression and rebound. I momentarily lost control and did not know what happened until pulling over and discovered front of car was sitting on the tires. I restarted car after several failed attempts to use the ride height leveling system controls and noticed all three ride height leveling lights flashing and then a suspension light flashing on operator…

Other Audi Allroad years

2020 2018 2017 2015 2014 2013 2005 200420032002 2001

Compare all Audi Allroad years · All Audi models

Frequently asked questions

Does the 2003 Audi Allroad have any recalls?

Yes — NHTSA lists 3 recalls for the 2003 Audi Allroad: 08V-157 (fuel system, gasoline), 06V-198 (electrical system), 04V-133 (electrical system). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2003 Audi Allroad?

Owners report electrical system problems most often (5 reports), followed by power train (4). The typical mileage when problems were reported is about 94,000 miles.

Are Audi recall repairs free?

Yes. Safety recall repairs are free at authorized Audi dealers, whether you are the first owner or bought the car used.