2004 Aprilia RSV 1000 recalls
Reported Nov 21, 2005 · 877 vehicles affected · APRILIA USA, INC.
Problem: On certain motorcycles, while in use the swing arm component may develop a stress fracture over an extended period of time.
Risk: If not replaced this will increase the risk of personal injuries or death.
Fix: Dealers will replace the swing arm component. The recall began in september 2006. Owners who have not had their motorcycle repaired will be renotified of this recall during august/september 2008. Owners may contact aprilia at 770-592-2261.
2004 Aprilia RSV 1000 problems reported by owners
| Problem area | Reports | |
|---|
| Suspension | 2 | |
| Fuel System, Gasoline | 2 | |
| Service Brakes, Hydraulic | 1 | |
Most reported parts
Typical mileage at the time of the problem: 11,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2004 Aprilia RSV 1000 complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Fuel System, Gasoline · at 11,000 miles · reported Jul 12, 2010
This is a follow up to claim #[xxx] . Aprilia has denied the replacement of my gas tank. At this point, the tank has spread around the gas cap, the seal between the tank and cap has a 2mm gap in between it and the tank, and the gas cap it self is recessing into the tank. Gas vapors have been escaping out of the cap area, making it difficult to breathe while riding at slow speeds. Excessive amounts of gas, enough to get in my riding gear is escaping. Aprilia has not contacted me, or made any move to remedy this. Possibly seeking legal action at this point, as the gas vapors pose a huge threat…
Fuel System, Gasoline · at 11,000 miles · reported Jun 15, 2010
2004 aprilia rsvr factory, see complaint #10334078 and all related. The fuel tanks are made by the same company as ducati of the same materials, my tank was taken to the dealership on concerns of drastically reduced mileage - from 45-50mpg to measured 15mpg and rippled/spread tank surface, aprilia denied my claim filed a couple of weeks ago at motocorsa of portland. Motocorsa advised me to file this complaint. Concerned spreading has caused somehow a leak or created pressure from spreading on a fuel line to affect gas mileage? Very concerned about riding this motorcycle and the potential loss…
Suspension · reported Oct 29, 2007
The contact owns a 2004 aprilia rsv 1000. The contact discovered that at low speeds, the rear suspension fails and the rear tire locks and slides under the seat. This causes the driver to lose control of the vehicle. He felt that certain aluminum parts should be steel and was due to a manufacturer defect. There had been no failure to date. The powertrain was unknown. The current mileage was 30,000.
Suspension · reported Aug 22, 2007
The contact owns a 2004 aprilia rsv 1000. A recall notice was received for NHTSA campaign # 05v538000 (Suspension:rear). A copy of the recall was faxed to the dealer, however; they had not contacted him back. The motorcycle was his only transportation therefore he was unable to leave the motorcycle with the dealer for them to order the part. There was no failure. The current mileage was 15,000.
Service Brakes, Hydraulic · reported Dec 21, 2006
2004 aprilia rsvr 1000 motorcycle - chronic rear brake problems. Brake line gets air trapped inside and will not work. Dealership has attempted to fix the issue many times. Repairs have lasted for several weeks and then reappear. The motorcycle is unsafe to ride with no rear brake.
Frequently asked questions
Does the 2004 Aprilia RSV 1000 have any recalls?
Yes — NHTSA lists 1 recall for the 2004 Aprilia RSV 1000: 05V-538 (suspension). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2004 Aprilia RSV 1000?
Owners report suspension problems most often (2 reports), followed by fuel system, gasoline (2). The typical mileage when problems were reported is about 11,000 miles.
Are Aprilia recall repairs free?
Yes. Safety recall repairs are free at authorized Aprilia dealers, whether you are the first owner or bought the car used.